石油化工高等学校学报

石油化工高等学校学报 ›› 2015, Vol. 28 ›› Issue (4): 60-64.DOI: 10.3969/j.issn.1006-396X.2015.04.013

• 油田化学 • 上一篇    下一篇

C P F E的表面和界面性质对破乳过程的影响

王 俊,  高振宇,  张志秋,  吴 松,  李翠勤   

  1.           
    ( 东北石油大学石油与天然气化工省重点实验室, 黑龙江大庆1 6 3 3 1 8)
  • 收稿日期:2014-12-27 修回日期:2015-04-08 出版日期:2015-08-25 发布日期:2015-08-25
  • 通讯作者: 李翠勤( 1 9 7 8 - ) , 女, 硕士, 副教授, 从事油田化学和精细化工领域的研究; E - m a i l : l i c u i q i n 7 8@1 6 3. c o m。
  • 作者简介:王俊( 1 9 6 5 - ) , 男, 博士, 教授, 从事油田化学和精细化工领域的研究; E - m a i l : w a n g j u n 1 9 6 5@y e a h. n e t 。
  • 基金资助:
    黑龙江省教育厅科技攻关项目( KY 1 2 0 1 2 4)

The Effect of Surface and Interfacial Properties of CPFE on Demulsification Process

  1. （Provincial Key Laboratory of Oil & Gas Chemical Technology，Northeast Petroleum University,Daqing Heilongjiang 163318, China）
  • Received:2014-12-27 Revised:2015-04-08 Published:2015-08-25 Online:2015-08-25

PDF

摘要： 以腰果酚和甲醛为原料合成腰果酚醛树脂起始剂, 再与环氧乙烷( EO) 和环氧丙烷( P O) 聚合, 合成腰 果酚醛树脂嵌段聚醚破乳剂( C P F E) 。采用表面张力法测定了C P F E的临界胶束浓度( c m c) 为8 0m g / L, 对应的表 面张力值( γ c m c) 为1 7. 3 8mN /m。采用旋滴法测定了C P F E的油 - 水界面张力, 考察了C P F E质量浓度和温度对油 - 水 界面张力的影响。结果表明, 随着C P F E质量浓度增加, 油 - 水界面张力显著下降; 随着温度升高, C P F E的界面活性 下降, 表明C P F E适合在低温环境下使用。采用单滴法测定了油滴破裂速率常数k随C P F E质量浓度的增加而增 大。

关键词: 腰果酚,  , 酚醛树脂聚醚,  , 破乳剂,  , 界面张力, 表面张力

Abstract: A cardanol phenolformaldehyde resin was synthesized using cardanol and formaldehyde as raw material, and the cardanol based phenolformaldehyde resin block polyether demulsifier (CPFE) was further synthesized using cardanol phenolformaldehyde resin as initiator through polymerization with epoxy propane (PO) and epoxyethane (EO), respectively. The crtical micelle concentration of CPFE was measured with the method of surface tension, and the results showed that the crtical micelle concentration of CPFE was 80 mg/L and the γcmc was 17.38 mN/m. The oilwater interfacial tension of CPFE was determined with a spinning drop tension meter. The influences of concentration and temperature on oilwater interfacial tensions were discussed in detail. Experimental results showed that the oilwater interfacial tension dereased obviously with the increase of concentration of CPFE, and the interfacial activity of CPFE dedined as temperature increased, which illustrated that the CPFE could be applied in low temperature environment. The oil droplet rupture constant k was measured by single droplet method, and the oil droplet rupture constant k increased with the increase of CPFE concentration. 

Key words: Cardanol,    , Phenolic resin polyether,     ,  Demulsifier,    ,  Interfacial tension,   , Surface tension

引用本文

王 俊, 高振宇, 张志秋, 吴 松, 李翠勤. C P F E的表面和界面性质对破乳过程的影响[J]. 石油化工高等学校学报, 2015, 28(4): 60-64.

Wang Jun, Gao Zhenyu, Zhang Zhiqiu, et al. The Effect of Surface and Interfacial Properties of CPFE on Demulsification Process [J]. Journal of Petrochemical Universities, 2015, 28(4): 60-64.

使用本文

0
    /   /   推荐

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://journal.lnpu.edu.cn/syhg/CN/10.3969/j.issn.1006-396X.2015.04.013

               https://journal.lnpu.edu.cn/syhg/CN/Y2015/V28/I4/60



网站版权 © 2021《石油化工高等学校学报》编辑部

地址：辽宁省抚顺市望花区丹东路西段1号 电话：024-56860967 E-mail:lnxuebao@126.com 邮编：113001

本系统由北京玛格泰克科技发展有限公司设计开发