适合三类油层的弱碱三元复合体系配方优选

doi:10.3969/j.issn.1006-396X.2020.02.007

石油化工高等学校学报 ›› 2020, Vol. 33 ›› Issue (2): 37-41.DOI: 10.3969/j.issn.1006-396X.2020.02.007

适合三类油层的弱碱三元复合体系配方优选

罗寒秋¹，姜婷婷²

1. 大庆油田有限责任公司第三采油厂，黑龙江大庆 163000； 2. 大庆油田有限责任公司第四采油厂，黑龙江大庆 163000

收稿日期:2018-05-15 修回日期:2018-06-02 出版日期:2020-04-28 发布日期:2020-05-22
作者简介:罗寒秋（1992-），男，从事油气田开发动态分析方面研究；E-mail：luohanqiu110@163.com。

Formulation of Weak⁃Alkaline ASP Flooding System Suitable for the Three Types of Oil Layers

Luo Hanqiu¹， Jiang Tingting²

1. The Third Oil Production Plant Test Team,Daqing Oilfield Limited Company,Daqing Heilongjiang 163000,China; 2. The Fourth Oil Production Plant Test Team,Daqing Oilfield Limited Company,Daqing Heilongjiang 163000,China;

Received:2018-05-15 Revised:2018-06-02 Published:2020-04-28 Online:2020-05-22

摘要/Abstract

摘要： 为进一步提高弱碱三元复合体系在大庆油田三类油层中的开发效果，需要对该体系的配方进行优选。采用CMG数值模拟与物理实验相结合的方法进行研究，在室内实验的基础上，对比分析了不同配方浓度对体系界面张力、乳化性能以及黏弹性的影响，确定了该体系配方的最优浓度，并进行了实验结果的机理分析与体系的适用性评价。结果表明，表面活性剂CHSB的质量分数在0.2%~0.3%时，所研究的弱碱三元复合驱体系能够实现超低界面张力，且在CHSB质量分数为0.3%时，体系的吸水率保持在40%以下，说明其具有良好的乳化性能；Na2CO3的质量分数为1.2%时测得的界面剪切黏弹性均为最佳。驱油实验的结果与数模结果互为验证，基于开发效果与经济评价，得到HPAM的质量浓度为2 000 mg/L，CHSB、Na2CO3的质量分数分别为0.3%、1.0%时的弱碱三元复配体系，室内驱油实验表明其能够有效提高采收率23.31%。该研究成果对弱碱三元复合驱在三类油层中的应用具有重要的指导作用。

关键词: 弱碱三元复合驱, 　三类油层, 　黏弹性, 　数值模拟, 　采收率

Abstract: In order to improve the development effect of the weak alkaline compound system in the three oil layers of Daqing Oilfield, it is necessary to optimize the formulation of compound system. Based on the combination of CMG numerical simulation and physical experiments, the effects of different concentration of formulation on the interfacial tension, emulsification performance and viscoelasticity of the system were compared and analyzed. The optimum concentration of the formulation was determined. The mechanism of the experimental results and the applicability of the system were also analyzed. The research indicates that the system can achieve ultra⁃low interfacial tension when the concentration of CHSB is between 0.2% and 0.3%, and the water absorption of the system remains below 40% when the concentration of CHSB is 0.3%, which indicates that the system has good emulsifying performance. The measured interfacial shear viscoelasticity is best when the Na2CO3 concentration is 1.2%. The results of the flooding experiment are mutually verified with the numerical simulation results. Based on development effectiveness and economic evaluation, the weak⁃alkaline ASP flooding system with the concentration of polymer HPAM is 1 000 mg/L, surfactant concentration of CHSB is 0.3%, and alkali concentration is 1.0%,which can increase the recovery rate by 23.31%. The results of this study have a guiding role in the application of weak⁃alkaline ASP flooding in the three oil layers.

Key words: Weak?alkaline ASP flooding system, Three types of oil layers, Viscoelasticity, Numerical simulation, Oil recovery

罗寒秋，姜婷婷. 适合三类油层的弱碱三元复合体系配方优选[J]. 石油化工高等学校学报, 2020, 33(2): 37-41.

Luo Hanqiu1， Jiang Tingting2. Formulation of Weak⁃Alkaline ASP Flooding System Suitable for the Three Types of Oil Layers[J]. Journal of Petrochemical Universities, 2020, 33(2): 37-41.

[1]	杨文武. B区块主力油层聚驱后变流线井网调整研究[J]. 石油化工高等学校学报, 2021, 34(2): 54-59.
[2]	张菁，庞艳萍，黎志敏，王志华. 气浮选对含油污水沉降分离流场特性的影响[J]. 石油化工高等学校学报, 2021, 34(1): 72-79.
[3]	田洋阳，张春影，牛振宇，何利民. 高含水旋转湍流场中油滴分散特性的数值模拟[J]. 石油化工高等学校学报, 2020, 33(6): 56-63.
[4]	王博，陈一鸣，杜胜男，王卫强. 基于CFD方法的无限大平板热扩散数值模拟[J]. 石油化工高等学校学报, 2020, 33(6): 79-84.
[5]	吴传昌，范飞，周晴晴，孔凡胜，申玲，管峰. 旋流筛板式流化床流化特性的数值模拟[J]. 石油化工高等学校学报, 2020, 33(6): 85-90.
[6]	赵洪鹏，姜贵璞. 裂缝性油藏微乳液配方优选及驱油效果[J]. 石油化工高等学校学报, 2020, 33(5): 42-47.
[7]	陈磊, 鲍文辉, 郭布民, 李梦, 孙厚台, 赵健. 缔合型超高温海水基压裂液的性能研究[J]. 石油化工高等学校学报, 2020, 33(4): 57-61.
[8]	杜明俊, 杨子宁, 滕彧, 马克迪, 焦亚东, 徐乙. 保温型井下隔热油管的实验及数值模拟研究[J]. 石油化工高等学校学报, 2020, 33(4): 75-79.
[9]	李波. 抗盐聚合物段塞优选及试验区见效分析[J]. 石油化工高等学校学报, 2020, 33(3): 37-42.
[10]	苏崭, 李玮, 黄红亮, 王旭东, 郑智冬. 储层岩石的三维逾渗模型研究[J]. 石油化工高等学校学报, 2020, 33(3): 60-66.
[11]	刘人玮, 杨天宇, 万宇飞, 蒋曙鸿, 黄喆. 海上平台热采放喷气扩散数值模拟研究[J]. 石油化工高等学校学报, 2020, 33(3): 74-79.
[12]	吴晓, 王兆婷, 史瑶. 水平管气液段塞流流动特征模拟[J]. 石油化工高等学校学报, 2020, 33(3): 80-85.
[13]	杨永超，吕昕倩，尚庆华，郭茂雷，白艳伟. 空气泡沫驱油藏含水及产气特征规律研究[J]. 石油化工高等学校学报, 2020, 33(2): 29-36.
[14]	张继成, 张军, 吕冰玉, 范佳乐. 钻关区生产动态变化规律——以B3区块为例[J]. 石油化工高等学校学报, 2020, 33(1): 23-29.
[15]	刘音颂，姚尚空，杨二龙. 大庆油田萨尔图中区西部合理地层压力研究[J]. 石油化工高等学校学报, 2019, 32(3): 82-86.

适合三类油层的弱碱三元复合体系配方优选

Formulation of Weak⁃Alkaline ASP Flooding System Suitable for the Three Types of Oil Layers

HTML

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics