甲酸络合萃取法脱除工业甲基萘中氮化物

石油化工高等学校学报 ›› 2007, Vol. 20 ›› Issue (1): 18-20.

甲酸络合萃取法脱除工业甲基萘中氮化物

熊杰明, 　张丽萍, 　龚良发

北京石油化工学院, 北京102617

收稿日期:2006-07-25 出版日期:2007-03-20 发布日期:2017-06-28
作者简介:熊杰明(1967 - ), 男, 四川泸州市, 副教授, 硕士
基金资助:
北京市属、市管高校人才强教计划资助项目(BJJWR20051102)

Removal of Nitrogen Compounds From Crude Methylnaphthalene Oil by Extraction With Formic Acid

XIONG Jie - ming,ZHANG Li - ping,GONG Liang - fa

Beijing Institute of Petrochemical Technology , Beijing 102617, P. R. China)

Received:2006-07-25 Published:2007-03-20 Online:2017-06-28

摘要/Abstract

摘要： 工业甲基萘中含有大量的氮化物杂质, 如喹啉、异喹啉、吲哚等, 可以通过甲酸络合萃取法脱除。考察了萃取时间、萃取温度、甲酸体积分数和剂油体积比等因素对萃取效果的影响。结果表明, 对于喹啉、异喹啉和甲基喹啉, 体系在3 min 内即达到萃取平衡;但对吲哚脱除, 则需要更长的时间。甲酸的体积分数对喹啉、异喹啉和甲基喹啉的萃取效果几乎没有影响, 但对吲哚的脱除有直接影响。甲酸体积分数越高, 对吲哚萃取效果越好。40 ℃以下吲哚的萃取效果较好。萃取过程甲基萘收率在95%以上, 该工艺为工业甲基萘脱氮找到了一个有效的办法。

关键词: 工业甲基萘, 　氮化物, 　络合萃取, 　甲酸

Abstract:

　The crude methylna phthalene oil (CM NO) contains some nitrogen impurities, such as quinoline , isoquinoline and indole and soon. The nitrogen compounds can be removed off efficiently from CM NO by extraction with formic acid.Experiment was carried out to investigate the effect of the extraction time , temperature , formic acid concentration , volume ratio of solvent to oil on extraction. The result shows that extraction system reaches equilibrium within 3 min for quinoline , isoquino line and methylquinoline , but needs longer time for indole , the formic acid concentration has little effect on removal of quinoline , isoquinoline and methylquinoline but has strong effect on removal of indole , the higher the formic acid concentration,the higher the indole removal efficiency , the removal efficiency for indole is higher below 40 ℃. The yield for me thylnaphthalene is more than 95%, which presents an effective method for removal of nitrogen compounds from CM NO.

Key words: Crude Methylnaphthalene oil , , Nitrogen Compounds , , Extraction , , Formic Acid

熊杰明, 　张丽萍, 　龚良发. 甲酸络合萃取法脱除工业甲基萘中氮化物[J]. 石油化工高等学校学报, 2007, 20(1): 18-20.

XIONG Jie - ming,ZHANG Li - ping,GONG Liang - fa. Removal of Nitrogen Compounds From Crude Methylnaphthalene Oil by Extraction With Formic Acid[J]. Journal of Petrochemical Universities, 2007, 20(1): 18-20.

[1]	李东胜,张毅,宋毅,翟玉春. 润滑油基础油糠醛精制工艺加助剂脱氮小试研究[J]. 石油化工高等学校学报, 2011, 24(1): 41-43.
[2]	熊杰明,迟姚玲,胡应喜,孙锦昌,任晓光. 过氧化氢/甲酸/硫酸体系氧化脱硫研究[J]. 石油化工高等学校学报, 2009, 22(3): 1-4.
[3]	熊杰明,冯慧,龚良发,张丽萍,任晓光. 用工业萘制备高纯萘产品的研究[J]. 石油化工高等学校学报, 2009, 22(1): 36-40.