石油化工高等学校学报

石油化工高等学校学报 ›› 2013, Vol. 26 ›› Issue (5): 10-14.DOI: 10.3969/j.issn.1006396X.2013.05.003

• 石油化工 • 上一篇    下一篇

顺酐加氢产物精制丁二酸的工艺研究

田丹1,霍稳周1,吕清林1,乔凯1,孟宪革2,李守田3   

  1. (1.中国石油化工股份有限公司抚顺石油化工研究院,辽宁抚顺113001;2.中国石油天然气股份有限公司抚顺石化公司,辽宁抚顺113008;3.中国石油抚顺石化公司洗涤剂化工厂,辽宁抚顺113001)
  • 收稿日期:1900-01-01 修回日期:1900-01-01 出版日期:2013-10-25 发布日期:2013-10-25
  • 作者简介:田丹（1984），女，辽宁抚顺市，硕士。
  • 基金资助:
    中国石油化工股份有限公司资助项目（210038）。

Purifying Technology of Succinic Acid from Product of Maleic Anhydride Hydrogenation

  1. （1.Fushun Research Institute of Petroleum and Petrochemicals, SINOPEC，Fushun Liaoning 113001, China; 2.PetroChina Fushun Petrochemical Company, Fushun Liaoning 113008, China; 3.Detergent Chemical Factory, PetroChina Fushun Petrochemical Company, Fushun Liaoning 113001, China）
  • Received:1900-01-01 Revised:1900-01-01 Published:2013-10-25 Online:2013-10-25

PDF

摘要： 对顺酐加氢产物精制丁二酸的工艺进行了研究。考察了蒸馏压力、蒸馏温度及回流比对减压蒸馏过 程的影响;考察了水解时间、水与酸酐物质的量比对水解过程的影响;考察了结晶温度对结晶过程的影响。确定了顺酐加氢产物减压蒸馏后水解结晶精制丁二酸的方法及工艺条件。结果表明,在减压蒸馏温度为75~85 曟,蒸馏压力为200~300Pa,水解温度为100曟,水与丁二酸酐物质的量比为4~5,水解时间为2h的条件下,得到的丁二酸产品收率曒70%,纯度曒99.5%。

关键词: 丁二酸,    , 减压蒸馏,    , 水解,   , 结晶

Abstract: The process of succinic acid purifying from product of maleic anhydride hydrogenation was studied. The effects of distillation pressure, temperature and reflux ratio on the process of vacuum distillation were investigated; it also discussed the effects of reaction time and molar ratio of water to succinic anhydride on hydrolysis; meanwhile, the effect of temperature on the crystallization was concerned. The pure succinic acid was acquired through vacuum distillation, hydrolyzation and crystallization. The process conditions of purifying technology of succinic acid were detemined. The results show that the yield of succinic acid is more than 70% and purity of the product can reach 99.5% even more under the conditions of vaccum distillation temperature 75~85 ℃, distillation pressure 200~300 Pa, hydrolysis temperature 100 ℃, molar ratio of water to succinic anhydride 4~5, reaction time 2 h.

Key words: Succinic acid,    ,  Vacuum distillation,    ,  Hydrolyzation,   ,  Crystallization

引用本文

田丹,霍稳周,吕清林,乔凯. 顺酐加氢产物精制丁二酸的工艺研究[J]. 石油化工高等学校学报, 2013, 26(5): 10-14.

TIAN Dan,HUO Wenzhou,LYU Qinglin,et al. Purifying Technology of Succinic Acid from Product of Maleic Anhydride Hydrogenation[J]. Journal of Petrochemical Universities, 2013, 26(5): 10-14.

使用本文

0
    /   /   推荐

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://journal.lnpu.edu.cn/syhg/CN/10.3969/j.issn.1006396X.2013.05.003

               https://journal.lnpu.edu.cn/syhg/CN/Y2013/V26/I5/10



网站版权 © 2021《石油化工高等学校学报》编辑部

地址：辽宁省抚顺市望花区丹东路西段1号 电话：024-56860967 E-mail:lnxuebao@126.com 邮编：113001

本系统由北京玛格泰克科技发展有限公司设计开发