Electrochemical Study of Q235 Steel in the Snow Water in North Region

doi:10.3696/j.issn.1672-6952.2011.03.017

Journal of Liaoning Petrochemical University ›› 2011, Vol. 31 ›› Issue (3): 62-65.DOI: 10.3696/j.issn.1672-6952.2011.03.017

Previous Articles Next Articles

Electrochemical Study of Q235 Steel in the Snow Water in North Region

LIANG Ping

School of Mechanical Engineering, Liaoning Shihua University, Fushun Liaoning 113001, P.R.China

Received:2011-03-22 Published:2011-09-25 Online:2017-07-05

北方地区雪水对Q235钢腐蚀性的电化学研究

梁平

辽宁石油化工大学机械工程学院,辽宁抚顺113001

作者简介:梁平(1974-),男,辽宁沈阳市,博士,副教授。

Abstract

Abstract:

The corrosion behavior of Q235 steel in the snow water, collected from North region, was studied by immersion, polarization curves and EIS, and the corrosion protection effect of Ni-Fe-P coating was tested. The results show that Q235 steel exhibits a general corrosion in the snow water, and the corrosion rate of Q235 steel in snow water is higher than that in tap water, because the conductivity of snow waster contained F^-, Cl^- and SO₄^2-is bigger than that of tap water. Meantime, the corrosion is lower than that of 3.5%NaCl solution because of the lower ion concentration for the snow water. In addition, the corrosion rate of Q235 steel in snow water was increased with increasing temperature. The EIS display that the charged transfer resistance of Ni-Fe-P electroless coating in snow water is bigger than that of Q235 steel, which means the corrosion rate is lower, and the coating can be one of methods used corrosion protection for Q235 steel in snow water or wet and serious polluted air.

Key words: Snow water , , Corrosion resistance , , Q235 steel , Ni-Fe-P electroless coating

摘要： 采用浸泡、动电位极化和交流阻抗等方法研究了Q235钢在北方地区雪水中的腐蚀行为,考察了Ni-
Fe-P化学镀层对Q235钢在雪水中腐蚀的防护效果。结果表明:Q235钢在雪水、自来水和质量分数3.5%NaCl溶
液中均表现为均匀腐蚀,但由于雪水中含有的氟化物、氯气、二氧化硫等物质溶解后产生了F-、Cl-和SO24- 等离子,
增加了雪水的导电性,使雪水的腐蚀速率高于自来水。同时,由于离子浓度相对较低,腐蚀性又低于NaCl溶液。温
度升高会加速Q235钢在雪水中的腐蚀。交流阻抗结果表明:Ni-Fe-P化学镀层比Q235钢在雪水中具有更大的
电荷转移电阻,表明该镀层具有更低的腐蚀速率,可以作为Q235钢在雪水或严重污染的潮湿空气中的防护措施。

关键词: 雪水, 耐蚀性, , Q235钢 , Ni-Fe-P化学镀层

LIANG Ping.

Electrochemical Study of Q235 Steel in the Snow Water in North Region

[J]. Journal of Liaoning Petrochemical University, 2011, 31(3): 62-65.

梁平. 北方地区雪水对Q235钢腐蚀性的电化学研究[J]. 辽宁石油化工大学学报, 2011, 31(3): 62-65.

[1]	Liang Jiling，Wang Liqun，Liu Lijuan，Tian Li，Zhang Lunqiu，Wang Weiqiang. The Modification of Fe3O4@SiO2 by Silane Coupling Agent and Performance [J]. Journal of Liaoning Petrochemical University, 2019, 39(6): 21-26.
[2]	Wang Yan， Nie Hong. Synchronous H _∞ Stabilization of TimeDelay Switched Systems under Partially DelayDependent Controllers [J]. Journal of Liaoning Petrochemical University, 2018, 38(04): 93-100.
[3]	Yang Fan, Li Yongfeng. Research Progress in Preparation and Catalytic Performance of the Carbon-Based Non Noble Metal Catalysts [J]. Journal of Liaoning Petrochemical University, 2018, 38(02): 1-8.
[4]	Wang Guoliang， Yi Chenglong. Fault Dependency Detection Method Based on Random Occurrence of Fault Signal [J]. Journal of Liaoning Petrochemical University, 2018, 38(02): 71-79.
[5]	. Removal of Sulfides from Simulated Oil by CH₃CONH₂/ZnCl₂ Deep Eutectic Solvent [J]. Journal of Liaoning Petrochemical University, 2017, 37(5): 1-7.
[6]	LiuYujuan,XuJi,TongYufei,et al. Progress in Research of the Synthesis Methods of Nanometer Ceria [J]. Journal of Liaoning Petrochemical University, 2017, 37(5): 8-12.
[7]	Liu Jindong,He Xin,Xin Dingye,et al. Change Law of Four Fractions in Residue Hydrotreating Catalyst Grading System [J]. Journal of Liaoning Petrochemical University, 2017, 37(5): 13-16.
[8]	Fu Yu,Li Xiaoou,Li Heming,et al. Enhanced Removal of the Mechanical Impurities in OilSandsOil  from Indonesia by UltrasoundSedimentation Method [J]. Journal of Liaoning Petrochemical University, 2017, 37(5): 17-21.
[9]	Wu Hao， Ma Guiyang， Xiang Nan，et al. The Effect Analysis of Settlement of Soil on Stress Fields of  Horizontal Section of Crossing Pipeline Structure [J]. Journal of Liaoning Petrochemical University, 2017, 37(5): 22-25.
[10]	Yan Rongju， Wang Weiqiang， Li Zimeng，et al. Progress of Severe Slugging in Marine Riser System [J]. Journal of Liaoning Petrochemical University, 2017, 37(5): 26-30.
[11]	Wang Long. Application of Seismic Reconstruction Inversion in Prediction of River  Channel of X Development Zone in Daqing Placantieline [J]. Journal of Liaoning Petrochemical University, 2017, 37(5): 31-37.
[12]	Zhu Bomin. Optimization of Well Spacing in Gaotaizi Reservoir  of Sazhong Development Zone [J]. Journal of Liaoning Petrochemical University, 2017, 37(5): 38-43.
[13]	Ma Jing,Jin Kejun,Liang Yufeng,et al. Study on Comprehensive Evaluation for Engineering  Mode of Offshore Oil and Gas Fields [J]. Journal of Liaoning Petrochemical University, 2017, 37(5): 44-48.
[14]	Fan Dengshuai,Gao Peng, Liu Zhihui，et al. A Method of Connection Reliability Analysis of Bolted Flange Systems [J]. Journal of Liaoning Petrochemical University, 2017, 37(5): 49-52.
[15]	Wu Zhiyong,Liu Yang,Gao Yang,et al. An Investigation on the Time Relaxation Parameter Used in Boiling  Simulation of Helical Coil Heat Exchanger ShellSide [J]. Journal of Liaoning Petrochemical University, 2017, 37(5): 53-60.

Electrochemical Study of Q235 Steel in the Snow Water in North Region

北方地区雪水对Q235钢腐蚀性的电化学研究

PDF

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics