Stress Analysis oft he Across Urban Gas PE Pipeline with Fixed Pier Based on the Finite Element Analysis

doi:10.3969/j.issn.1672-6952.2017.01.005

Journal of Liaoning Petrochemical University ›› 2017, Vol. 37 ›› Issue (1): 24-29.DOI: 10.3969/j.issn.1672-6952.2017.01.005

Previous Articles Next Articles

Stress Analysis oft he Across Urban Gas PE Pipeline with Fixed Pier Based on the Finite Element Analysis

Received:2016-04-21 Revised:2016-06-20 Published:2017-02-24 Online:2017-03-16

基于有限元分析的PE燃气管道有固定墩的跨越段应力分析

刘睿,赵玲,吴明,刘广鑫,宋博强,高姿乔

辽宁石油化工大学石油天然气工程学院,辽宁抚顺113001

通讯作者: 吴明(1961-),男,博士,教授,博士生导师,从事管道泄漏与分析方面的研究;E-mail:wuming0413@163.com。
作者简介:刘睿(1990-),女,硕士研究生,从事管道完整性方面的研究;E-mail:938763460@qq.com。
基金资助:
国家质检总局科研项目(201310159)。

Abstract

Abstract:

Aimed at the mechanical properties research of the polyethylene gas pipeline with the fixed pier had important significance to the urban gas network safety. Based on the theory of the finite element analysis, a simulate model of the polyethylene pipeline was set up. The polyethylene pipeline was simulated by using engineer analysis software ANSYS, the influence of change in the span length, diameter and internal pressure on the deformation and stress of the pipeline were analyzed. The results showed that the midspan deflection of pipeline increased slowly when the span length was below 15 m. But when the span was more than 15 m, the deflection increased sharply. The stress of the pipe also increased with the pipe span increasing. But the growth was stable relatively. Changes of diameter also impacted midspan deflection and stress. The midspan deflection and stress were decreased with the increase of pipe diameter. The internal pressure had little influence on the midspan deflection of the pipeline. But the stress of the pipe increased with the increase of the internal pressure.

Key words: PE pipeline, Crossing pipeline, Fixed pier, Midspan deflection, Stress, ANSYS

摘要： 研究有固定墩的聚乙烯燃气跨越管道力学性能,对城镇燃气管网的安全运行具有重要意义。基于有限元分析理论,建立了两端设有固定墩的聚乙烯跨越管道仿真模型,运用工程分析软件ANSYS对聚乙烯燃气管道进行模拟,分析并讨论了跨长、管径以及内压等因素对管道变形和应力的影响及其变化规律。研究结果表明,管道跨中挠度在跨长低于15m 时增加缓慢,但是当跨度大于15m 时,管道的跨中挠度会急剧增加;管道所受的应力随着管道跨度的增加而增加,但是增长相对平稳;管径对管道的跨中挠度和应力也有影响,管道的跨中挠度和应力均随着管径的增大而减小;管道内压对管道的跨中挠度影响较小,几乎没有变化,但是管道所受应力随着管道内压的增大而增大。

关键词: 聚乙烯管道, 跨越管道, 固定墩, 跨中变形量, 应力, ANSYS

LiuRui, ZhaoLing, WuMing, LiuGuangxin, SongBoqiang, GaoZiqiao. Stress Analysis oft he Across Urban Gas PE Pipeline with Fixed Pier Based on the Finite Element Analysis[J]. Journal of Liaoning Petrochemical University, 2017, 37(1): 24-29.

刘睿, 赵玲, 吴明, 刘广鑫, 宋博强, 高姿乔. 基于有限元分析的PE燃气管道有固定墩的跨越段应力分析[J]. 辽宁石油化工大学学报, 2017, 37(1): 24-29.

[1]	Xiaodong LU, Wei CHEN, Peijuan SHANG, Yijie WANG, Yongli PANG, Wei XIE, Junjie CAO, Qiyu HUANG. The Influence of Scale on the Strength of Wax Deposits and the Pigging Characteristics of Polyethylene Pipeline [J]. Journal of Liaoning Petrochemical University, 2024, 44(4): 33-43.
[2]	Jiaxu WANG, Qi LIU, Jianghua TAO, Dongxu SUN, Chunxiao ZHANG, Yulin YAN, Zhiyong HU. Thermal Stress and Fatigue Life Analysis of Cold and Hot Crude Oil Pipeline [J]. Journal of Liaoning Petrochemical University, 2024, 44(1): 49-54.
[3]	Zhunshun Zhang, Qiang Guo, Guiyang Ma, Yang Li, Hongwei Chen. Simulation Study on Improving the Safety of Heat Exchanger by Adding Thermal Insulation Layer at the Pipe End [J]. Journal of Liaoning Petrochemical University, 2023, 43(2): 67-71.
[4]	Junchi Li, Fei Xie. Study of Stress Corrosion Cracking Behavior of X70 Pipeline Steel in CO₂ Enhanced Mining Environment [J]. Journal of Liaoning Petrochemical University, 2023, 43(1): 38-42.
[5]	Zhiwei Zhao, Wenquan Jiang, Junfeng Guo, Yanhai An, Zhi Li, Yao Zhang. Crack Failure Analysis of Torch Burner Pipeline in Petrochemical [J]. Journal of Liaoning Petrochemical University, 2022, 42(5): 80-83.
[6]	Songyu Yang, Yili Duo, Tie Sun, Chengbin Wang. Finite Element Analysis of Influence of Nut Washer on Stress Distribution of Bolt Flange Joint [J]. Journal of Liaoning Petrochemical University, 2022, 42(3): 62-67.
[7]	Chengbin Wang, Yili Duo, Tie Sun, Songyu Yang. High Temperature Bolted Flange Connection Structure and Risk Analysis [J]. Journal of Liaoning Petrochemical University, 2022, 42(2): 67-72.
[8]	Zhenyu Cheng, Dan Wang, Fei Xie, Jintao Jiang, Haiyan Yang. Study of CO₂ Corrosion Behavior under Oil⁃Water Two⁃Phase Flow System [J]. Journal of Liaoning Petrochemical University, 2022, 42(1): 41-46.
[9]	Aibin Zhao, Yuanyuan Zhang, Ronghua Li. Numerical Simulation and Experimental Verification of Carburizing⁃Quenching of Gear Made of 20CrMnTi Steel [J]. Journal of Liaoning Petrochemical University, 2022, 42(1): 59-63.
[10]	Zhijun Xu, He Zhang, Ning Luo. Study on of Internal Characteristics Detection of Weak Magnetic Stress in Pipelines under Excitation of External Magnetic Field [J]. Journal of Liaoning Petrochemical University, 2021, 41(5): 55-60.
[11]	Ye Tian, Ning Luo, Jian Liu, He Zhang, Kang Zhao, Kun Li. Research on Detection Stress Technology of Residual Magnetic Based on Coercive Force [J]. Journal of Liaoning Petrochemical University, 2021, 41(4): 85-90.
[12]	Liu Zhe， Chen Shouzhi， Zhang Juwei， Cui Shuang, Bao Ruixin. Finite Element Analysis of Pressure Vessel Joint Structure under External Load [J]. Journal of Liaoning Petrochemical University, 2021, 41(1): 68-72.
[13]	Wu Wanjin， Zhang Juwei. Buckling Mode Analysis of Floating Roof Storage Tank under Wind Load [J]. Journal of Liaoning Petrochemical University, 2020, 40(2): 78-82.
[14]	Lü Jing, Yan Ping, Cao Enming, Wang Guoqing. The Stress Testing Technology for Pipeline Based on Weak Magnetic Effect [J]. Journal of Liaoning Petrochemical University, 2020, 40(1): 72-77.
[15]	Liu Xu，Wang Yue. Stress Calculation of Pipeline under Flood Disaster [J]. Journal of Liaoning Petrochemical University, 2019, 39(6): 48-53.

Stress Analysis oft he Across Urban Gas PE Pipeline with Fixed Pier Based on the Finite Element Analysis

基于有限元分析的PE燃气管道有固定墩的跨越段应力分析

PDF

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics