水溶性咪唑啉季铵盐缓蚀剂的复配研究

辽宁石油化工大学学报 ›› 2008, Vol. 28 ›› Issue (4): 16-19.

水溶性咪唑啉季铵盐缓蚀剂的复配研究

孙菱翎1，李东胜1，李晓鸥1*，刘洁1，王慧2

1.辽宁石油化工大学，辽宁抚顺 113001|2.华东理工大学，上海 200237

收稿日期:2008-05-30 出版日期:2008-12-20 发布日期:2017-07-25

Exploitation and Research of the Water Soluble Imidazolinylquaternary-Ammonium-Salt Corrosion Inhibitor

SUN Ling-ling1， LI Dong-sheng1， LI Xiao-ou1*， LIU Jie1， WANG Hui2

1. Liaoning University of Petroleum & Chemical Technology, Fushun Liaoning 113001，P.R.China; 2. East China University of Science, Shanghai 200237, P.R.China

Received:2008-05-30 Published:2008-12-20 Online:2017-07-25

摘要/Abstract

摘要： 利用正交实验方法对复配缓蚀剂进行了开发与研究，以环烷酸和多乙烯多胺合成的缓蚀剂为主要成份，再与表面活性剂、螯合物、有机胺和自制液进行复配而得；采用多元二次回归方程式对合成产物腐蚀速率与操作[CM(49*2]因素的关系进行回归；用非线性规化确定出实验范围内腐蚀速率最小的适宜复配操作条件：表面活性剂用量为[CM)]0.112 6（与合成缓蚀剂的质量比，下同），螯合剂用量为0.010 2，有机胺用量为0.213 9，自制液用量为0.357 2。验证实验结果表明，在最适宜的实验配比下所得产品其水溶性好、腐蚀速率慢、缓蚀率高达99%以上。

关键词: 咪唑啉季铵盐缓蚀剂, 复配, 水溶性, 缓蚀率 

Abstract: Exploitation and research of compositive product, i.e. Corrosion Inhibitor, was carried out by the mixing of the main component of corrosion inhibitor with surfactants, chelate, organic amine and liquid of prefabrication, then the optimal proportion was found out in order to build the best matching systems. The models among the anti-corrosive capacity of the inhibitor and operation conditions were established by polynary quadratic regression. The optimum operation conditions obtained by non-linear programming (NLP) are the following: the amount of the surfactants, chelate, organic amine and the liquid of prefabrication is 0.112 6, 0.010 2, 0.213 9 and 0.357 2 respectively. The verified experiment showed that the products under the optimum operation conditions had the better water-soluble capablity, slower corrosion rate and higher anti-corrosive capacity (up to over 99%).

Key words: Imidazoline quaternary-ammonium-salt corrosion inhibito, Surfactant, Water-soluble, Corrosion inhibition efficiency

孙菱翎，李东胜，李晓鸥，刘洁，王慧. 水溶性咪唑啉季铵盐缓蚀剂的复配研究[J]. 辽宁石油化工大学学报, 2008, 28(4): 16-19.

SUN Ling-ling， LI Dong-sheng， LI Xiao-ou， LIU Jie， WANG Hui. Exploitation and Research of the Water Soluble Imidazolinylquaternary-Ammonium-Salt Corrosion Inhibitor[J]. Journal of Liaoning Petrochemical University, 2008, 28(4): 16-19.

[1]	万雯绯, 马贵阳, 臧春阳, 敖迪. SDBS与APG1214复配对稠油协同增效的影响[J]. 辽宁石油化工大学学报, 2024, 44(5): 15-21.
[2]	王晨宇, 樊迪, 马贵阳. IAEC⁃1306H复配体系对稠油黏度的影响[J]. 辽宁石油化工大学学报, 2021, 41(5): 61-65.
[3]	吕文怡，吴玉国，张梦轲，刘萌，杨鸿麟. 曲拉通与甜菜碱复配对稠油乳化降黏的影响[J]. 辽宁石油化工大学学报, 2019, 39(3): 22-25.
[4]	戴名扬，吴玉国，李小玲，崔连来，吴玉良. 应用OP⁃12复配型乳化剂的辽河稠油乳化降黏实验研究[J]. 辽宁石油化工大学学报, 2019, 39(1): 10-14.
[5]	王卫强，丁影影，孙翊赫，姜卫山，王国付. 复配菌对含蜡原油微观结构影响分析[J]. 辽宁石油化工大学学报, 2018, 38(05): 24-29.
[6]	段月英,丛玉凤,黄玮,赵红丽,唐东,白双福,郭金鹏,高瞩. 液体石蜡的乳化研究[J]. 辽宁石油化工大学学报, 2016, 36(5): 6-9.
[7]	朱珠,赵德智,宋官龙,贺颜梅,赵春晓,李思洋,田野. 三元相图分析乳化柴油稳定性[J]. 辽宁石油化工大学学报, 2014, 34(3): 29-32.
[8]	李长波,薛懂,姜虎生,张洪林,刘邓超. 复合混凝剂处理印染废水的实验研究[J]. 辽宁石油化工大学学报, 2014, 34(2): 1-3.
[9]	梁路,李丽华,张金生,王婧. 复合油井水泥早强剂L L的室内研究[J]. 辽宁石油化工大学学报, 2014, 34(2): 33-36.
[10]	杨丽娜,刘思秀. 直馏柴油复合脱酸剂研究[J]. 辽宁石油化工大学学报, 2011, 31(1): 17-20.