石油化工高等学校学报

石油化工高等学校学报 ›› 2010, Vol. 23 ›› Issue (4): 38-43.DOI: 10.3696/j.issn.1006-396X.2010.04.009

• 石油化工 • 上一篇    下一篇

NaHSO4·H2O催化蓖麻油酯交换制备生物柴油动力学

靳福全,牛宇岚,商云岩,孙立田,刘潘   

  1. 太原工业学院化学与化工系,山西太原030008
  • 收稿日期:2010-07-01 修回日期:2010-09-20 出版日期:2010-12-25 发布日期:2010-12-25
  • 作者简介:靳福全(1957 -), 男, 山西忻州市, 副教授, 硕士
  • 基金资助:
    山西省科技攻关项目(2007031137);山西省教育
    厅科技研发项目(2010130)

Kinetics of Transesterification of Castor Oil to Biodiesel Using NaHSO4·H2O as a Catalyst

  1. Department of Chemistry and Chemical Engineering，Taiyuan Institute of Technology，Taiyuan Shanxi 030008，P.R.China
  • Received:2010-07-01 Revised:2010-09-20 Published:2010-12-25 Online:2010-12-25

PDF

摘要： 采用过量浓度法对一水硫酸氢钠催化蓖麻油与甲醇酯交换反应宏观动力学进行了研究。考察了不同温度下蓖麻油转化率和时间的关系以及甲醇转化率和时间的关系。用高效液相色谱仪测定了不同反应时刻系统的甲酯含量。用线性回归方法处理实验数据得出:蓖麻油分级数为1.5, 甲醇分级数为0.5 ;当反应温度为303、313、 323 、333 K , 催化剂加入量为油质量的5 %, 搅拌速率为600 r/ min 时, 表观速率常数分别为:0.003 934、0.005 271、 0.006 656、0.008 237 dm3/(mol · min), 表观活化能为20 .627 kJ/ mol, 表观频率因子为14.280 6 dm3/(mo l· min)。动力学方程的预测结果和实验结果吻合较好。

关键词: 一水硫酸氢钠 , 催化 , 蓖麻油 , 生物柴油 , 动力学

Abstract: Macrokinetics of transesterification of castor oil with methanol was studied in the presence of NaHSO4·H2O catalyst using method of excessive concentration. The relationship between castor oil conversion and reaction time and the relationship between methanol conversion and reaction time were investigated at different temperature.Methyl ester contents in the system at different reaction time were determined by high-performance liquid chromatography.The experimental data were dealt with linear regression method. The results show that reaction order is 1.5 for castor oil and is 0.5 for methanol,and that under the conditions of reaction temperature 303,313,323,333 K,mass ratio of catalyst to oil 5%,agitation speed 600 r/min, the apparent rate constant is 0.003 934,0.005 271,0.006 656,and 0.008 237 dm3/(mol·min) ,respectively, the apparent activation energy is 20.627 kJ/mol and the apparent frequency factor is 14.2806 dm3/(mol·min).The results predicted by the kinetic equition are in good agreement with the experimental results.

Key words:

引用本文

靳福全,牛宇岚,商云岩. NaHSO4·H2O催化蓖麻油酯交换制备生物柴油动力学[J]. 石油化工高等学校学报, 2010, 23(4): 38-43.

JIN Fu-quan， NIU Yu-lan， SHANG Yun-yan，et al. Kinetics of Transesterification of Castor Oil to Biodiesel Using NaHSO4·H2O as a Catalyst[J]. Journal of Petrochemical Universities, 2010, 23(4): 38-43.

使用本文

0
    /   /   推荐

导出引用管理器 EndNote|Ris|BibTeX

链接本文: http://journal.lnpu.edu.cn/syhg/CN/10.3696/j.issn.1006-396X.2010.04.009

               http://journal.lnpu.edu.cn/syhg/CN/Y2010/V23/I4/38



网站版权 © 2021《石油化工高等学校学报》编辑部

本系统由北京玛格泰克科技发展有限公司设计开发