氧化蜡制备皮革用蜡

辽宁石油化工大学学报 ›› 2007, Vol. 27 ›› Issue (3): 4-6.

氧化蜡制备皮革用蜡

黄玮1，李长征2

1.辽宁石油化工大学环境与生物工程学院，辽宁抚顺 113001； 2.中国人民解放军驻抚顺石化公司军事代表室，辽宁抚顺113008

收稿日期:2007-01-22 出版日期:2007-09-20 发布日期:2017-07-23

Preparation of Leather Wax by Oxidized Paraffin Wax

HUANG Wei1, LI Chang-zheng2

1.School of Environmental and Biological Engineering, Liaoning University of Petroleum & Chemical Technology, Fushun Liaoning 113001, P.R.China； 2.PLA Representative Office at Fushun Petrochemical，Fushun Liaoning 113008, P.R.China

Received:2007-01-22 Published:2007-09-20 Online:2017-07-23

摘要/Abstract

摘要： 采用石蜡和微晶蜡为原料，经催化氧化反应研制出氧化蜡，其质量和性能与天然巴西棕榈蜡相似。在表面活性剂的作用下，以氧化蜡为原料，水作为溶剂，经乳化反应制备出皮革用上光、去污乳化蜡。同时考察了乳化剂的种类、用量，制备乳化蜡的搅拌速度，乳化时间、温度等因素对乳化蜡稳定性的影响。研究结果表明，当氧化蜡、乳化剂、助乳化剂的质量比为1∶0.3∶0.000 2，乳化时间为20 min，搅拌速度为500～1 000 r／min，乳化温度为85～90 ℃时，得到的皮革用乳化蜡产品涂层均匀、性能优异，与使用天然巴西棕榈蜡相比成本较低。

关键词: 催化氧化, 上光, 去污, 乳化蜡

Abstract: A mass proportion paraffin and microcrystalline wax was adopted as raw material, and under certain conditions catalyzed oxidation reaction took place, a sample which qualify and performance similar to that of natural carnauba wax was obtained. By using oxidation wax as experimental material and water as solvent, under the surfactants’action, after the reaction of emulsification, polishing and decontaminating wax for leather was prepared. Then some factor's effects on stability of emulsifying wax, such as emulsifier type, quantity, stirring speed, emulsifying time and emulsifying temperature were discussed. The results show that when the dosage of oxidation wax: the mass fraction of auxiliary,emulsifier and emulsifier is 1∶0.3∶0.000 2, emulsifying time is 20 min, stirring speed is 500～1 000 r/min, emulsifying temperature is 85～90 ℃, the wax for leather whose feature is well-distributed, well function and low cost which compared with the natural carnauba wax is obtained.

Key words: Catalysis oxidation, Polishing, Decontamination, Emulsified wax

黄玮，李长征. 氧化蜡制备皮革用蜡[J]. 辽宁石油化工大学学报, 2007, 27(3): 4-6.

HUANG Wei, LI Chang-zheng. Preparation of Leather Wax by Oxidized Paraffin Wax[J]. Journal of Liaoning Petrochemical University, 2007, 27(3): 4-6.

[1]	高伟, 曾欣, 李金晓, 杨春花, 王雅琪, 李谡民, 吕爽, 潘立卫. Pt/γ⁃Al₂O₃催化剂低温催化甲醇氧化研究[J]. 辽宁石油化工大学学报, 2023, 43(6): 44-47.
[2]	于东北, 李学, 杨昕毓, 张财顺, 韩蛟, 王宏浩, 张磊, 高志贤. 沉淀剂对CuO/CeO₂催化剂织构性质及CO催化氧化性能的影响[J]. 辽宁石油化工大学学报, 2023, 43(6): 48-53.
[3]	宋健伟, 张晶, 檀凯文, 潘立卫, 钟和香. 水处理中非均相臭氧氧化催化剂的研究进展[J]. 辽宁石油化工大学学报, 2022, 42(3): 8-13.
[4]	陈可先，尹璐，谢海英. 含氮六元杂环氮氧自由基有机催化剂的结构与活性关系[J]. 辽宁石油化工大学学报, 2017, 37(6): 1-5.
[5]	齐书磊,徐安琪,周明东,王景芸,王欣. B r ø n s t e d酸功能化有机高铼酸盐催化氧化硫醚的研究[J]. 辽宁石油化工大学学报, 2015, 35(3): 1-5,9.
[6]	阮本玺,沈健,李少凯,聂宁. 铌改性SBA灢15催化氧化FCC汽油脱硫[J]. 辽宁石油化工大学学报, 2013, 33(3): 24-27.
[7]	林姝琦,朱大禹,宫召君,陈文艺. 新型皮革去污上光用乳化蜡的研究[J]. 辽宁石油化工大学学报, 2009, 29(2): 6-7.
[8]	丛玉凤, 黄　玮, 廖克俭. 天然巴西棕榈蜡替代品的合成[J]. 辽宁石油化工大学学报, 2007, 27(1): 27-29.
[9]	陈　平, 权成光. 皮革上光乳化蜡的研制[J]. 辽宁石油化工大学学报, 2005, 25(2): 9-12.