石油化工高等学校学报

石油化工高等学校学报 ›› 2014, Vol. 27 ›› Issue (4): 16-20.DOI: 10.3969/j.issn.1006-396X.2014.04.004

• 石油化工 • 上一篇    下一篇

B r ö n s t e d酸性离子液体催化合成硬脂酸异辛酯

王兴之1,  左臣盛1,  宋 燊2,  曹淑云1,  孙宏月1,刘 丹1,  刘道胜1,  桂建舟1   

  1. ( 1. 辽宁石油化工大学化学与材料科学学院, 辽宁抚顺1 1 3 0 0 1; 2. 中国寰球工程公司辽宁分公司, 辽宁抚顺1 1 3 0 0 6)
  • 收稿日期:2013-09-28 修回日期:2014-03-28 出版日期:2014-08-25 发布日期:2014-11-10
  • 通讯作者: 桂建舟( 1 9 7 3 - ) , 男, 博士, 教授, 从事石油化工催化剂及工艺的研究; E - m a i l : j z g u i @h o t m a i l . c o m。
  • 作者简介:王兴之( 1 9 8 8 - ) , 女, 硕士研究生, 从事功能化离子液体的研究; E - m a i l : w a n g x i n g z h i 0 4 2 4@1 6 3. c o m。
  • 基金资助:
    国家自然科学基金项目 ( 2 1 1 0 3 0 7 7) ; 新世纪优秀人才支持计划( NC E T - 1 1 - 1 0 1 1) ; 辽宁省优秀人才支持计划
    ( L R 2 0 1 0 2 4和 L J Q 2 0 1 1 0 3 5) ; 辽宁自然科学基金项目( 2 0 1 1 0 2 1 2 0和2 0 1 2 0 2 1 2 3) 。

Synthesis of 2Ethylhexyl Stearate Using Brnsted Acidic Ionic Liquid as Catalyst

  1. (1.College of Chemistry and Material Science, Liaoning Shihua University, Fushun Liaoning 113001，China;  2. China Huanqiu Contracting & Engineering Liaoning Company, Fushun Liaoning 113006,China)
  • Received:2013-09-28 Revised:2014-03-28 Published:2014-08-25 Online:2014-11-10

PDF

摘要： 以硬脂酸和异辛醇为原料, B r ö n s t e d酸性离子液体为催化剂, 合成硬脂酸异辛酯, 考察反应条件和催 化剂重复使用情况。结果表明, 在反应温度1 5 0℃, 反应时间6h, 酸醇物质的量比1∶1. 4, 离子液体与硬脂酸物质的 量比为1∶2 5时, 酯化率高达9 6. 9%, 产品酸值小于0. 5m g( KOH) / g。反应结束后, 产物和催化剂分层, 通过简单的 倾倒即可分离, B r ö n s t e d酸性离子液体经真空干燥回收后可重复使用, 且循环使用6次后, 催化活性基本不变。

关键词: 硬脂酸异辛酯,    ,  , 离子液体,    , 酯化反应

Abstract: 2Ethylhexyl stearate was synthesized by esterification of stearic acid with 2ethylhexanol using Brnsted acidic ionic liquid as catalyst. The conditions of the synthesis and the recycling capability of the catalyst were investigated. The results indicated that Brnsted acidic ionic liquid possessed high catalytic activity for the esterification reaction. The optimal synthesis conditions were as follows: the reaction temperaturewas at 150 ℃, the reaction time was 6 h, the molar ratio of stearic acid to 2ethylhexanol was 1∶1.4, and the molar ratio of catalyst to stearic acid was 1∶25. On this condition, the conversion rate was up to 96.9% and the acid value of the product was smaller than 0.5 mg（KOH）/g. After the reaction, the ester could be simply decanted out from the ionic liquid, and the ionic liquid could be reused after removal of water under vacuum. The activity of the catalyst remained at a high level after reuse of six cycles. 

Key words: 2Ethylhexyl stearate,    ,  Ionic liquid,    ,  Esterification

引用本文

王兴之, 左臣盛, 宋 燊. B r ö n s t e d酸性离子液体催化合成硬脂酸异辛酯[J]. 石油化工高等学校学报, 2014, 27(4): 16-20.

Wang Xingzhi,Zuo Chensheng,Song Shen,et al. Synthesis of 2Ethylhexyl Stearate Using Brnsted Acidic Ionic Liquid as Catalyst[J]. Journal of Petrochemical Universities, 2014, 27(4): 16-20.

使用本文

0
    /   /   推荐

导出引用管理器 EndNote|Ris|BibTeX

链接本文: http://journal.lnpu.edu.cn/syhg/CN/10.3969/j.issn.1006-396X.2014.04.004

               http://journal.lnpu.edu.cn/syhg/CN/Y2014/V27/I4/16



网站版权 © 2021《石油化工高等学校学报》编辑部

本系统由北京玛格泰克科技发展有限公司设计开发