稠油热采过程中余热资源的高效回收与利用

辽宁石油化工大学学报 ›› 2013, Vol. 33 ›› Issue (1): 60-63.

稠油热采过程中余热资源的高效回收与利用

姚尧¹,吴明¹,贾冯睿^1* ,王雷¹,高艳波¹,冯锦烨²,刘黎³

1.辽宁石油化工大学石油天然气工程学院,辽宁抚顺113001;2.中国石油抚顺石化分公司抚顺化工塑料厂,
辽宁抚顺113000;3.中国石油吉林油田储运销售公司,吉林松原138000

收稿日期:2012-08-31 出版日期:2013-03-25 发布日期:2017-07-14
作者简介:姚尧(1987-),男,宁夏青铜峡市,在读硕士

High Efficiency Recycling and Utilization for Residual Heat Resources in Heavy Reservoir Thermal Recovery Process

YAO Yao¹， WU Ming ^!， JIA Fengrui^1*， WANG Lei¹， GAO Yanbo^*， FENG Jinye²， LIU Li³

1.College of Petroleum Engineering, Liaoning Shihua University, Fushun Liaoning 113001, China； 2.China petroleum fushun petrochemical branch fushun chemical plastics plant, Fushun Liaoning 113000, China； 3. Dutage Marketing Company of Jilin Oilfield Company, CNPC,Songyuan Jilin 138000, China

Received:2012-08-31 Published:2013-03-25 Online:2017-07-14

摘要/Abstract

摘要： 针对稠油热采过程中大量低温余热资源的浪费问题,提出了利用热泵技术回收油田污水余热用于稠
油伴热管道输送的工艺,并运用Matlab飊Simulink软件对该工艺进行了动态仿真模拟,得到了工艺系统的制热系数。
研究结果表明,该工艺系统的制热温度可达75曟,能满足稠油输送伴热水温度的要求,且系统平均制热系数为3.5。
在此基础上,还进行了能耗分析。分析结果表明,所设计的基于热泵技术的余热回收系统可比锅炉加热方式节省标
煤17t/a,减少向空气中排放的污染物0.714t/a,具有非常大的经济效益和环境效益。

关键词: Matlab-Simulink仿真 , 热泵系统 , 余热回收 , 污水

Abstract: Considering the large resource of low temperature waste heat in heavy reservoir thermal recovery process, the technology of recover waste heat in oil field was used for heating pipeline in heavy oil transportation. The model of dynamic simulation system of the technology was established by MatlabSimulink, and the heating efficiency of the technology system was obtained. The results of the study show that the heating temperature of system can achieve 75 ℃, satisfied with the temperature requirements of heating water in heavy oil transportation, and the heating coefficient of system is 3.5. Based on this, through the analysis of the energy that the established system model can save standard coal 17 t/a better than boiler heating model, to reduce the discharge of pollutants in the air 0.714 t/a, the system has a large economic and environmental benefits.

Key words: MatlabSimulink simulation , Heat pump system , Waste heat recovery , Sewage

姚尧,吴明,贾冯睿,王雷,高艳波,冯锦烨,刘黎. 稠油热采过程中余热资源的高效回收与利用[J]. 辽宁石油化工大学学报, 2013, 33(1): 60-63.

YAO Yao， WU Ming1，JIA Fengrui1，WANG Lei， GAO Yanbo， FENG Jinye，LIU Li3. High Efficiency Recycling and Utilization for Residual Heat Resources in Heavy Reservoir Thermal Recovery Process[J]. Journal of Liaoning Petrochemical University, 2013, 33(1): 60-63.

[1]	陈旭阳, 杨帆, 姜文全, 郑皓天, 田大微. 基于LNG冷能的卡琳娜⁃三级有机朗肯循环性能分析[J]. 辽宁石油化工大学学报, 2024, 44(5): 90-96.
[2]	何依, 邹斌, 张丽, 商丽艳, 李萍, 潘振. 基于LNG冷能的双循环⁃卡琳娜冷电联供系统[J]. 辽宁石油化工大学学报, 2020, 40(1): 43-51.
[3]	于慧鹏,刘宝玉,万逵芳,梁源,吕荣杭,范文琳. 电厂锅炉高温炉渣余热回收利用技术[J]. 辽宁石油化工大学学报, 2013, 33(1): 43-47.
[4]	金文英,赵宇,金珊. 膜过滤复合过程污染阻力分析及清洗[J]. 辽宁石油化工大学学报, 2010, 30(2): 4-7.
[5]	李洪敏,娄世松,张凤华,李飞,李秋红,赵杉林. 聚结—气浮法处理含油污水[J]. 辽宁石油化工大学学报, 2009, 29(4): 1-3.
[6]	陈敬润,刘志红,崔秀霞,张洪林,刘丹. 中试一体化膜生物反应器系统处理生活污水[J]. 辽宁石油化工大学学报, 2009, 29(1): 8-10.
[7]	张晶，胡春玲，林峰，付强. 高负荷活性污泥法中试试验研究[J]. 辽宁石油化工大学学报, 2008, 28(2): 18-21.
[8]	宋　波, 丁保宏. 聚硅酸铝絮凝处理医院污水[J]. 辽宁石油化工大学学报, 2006, 26(2): 49-51.