Extraction Desulfurization with Synthesized Lews⁃Brönsted Deep Eutectic Solvent at Room Temperature

doi:10.3969/j.issn.1006-396X.2022.04.005

Abstract

Abstract:

A deep eutectic solvent was synthesized by the stirring method with Br?nsted acid (carboxylic acid) and Lews acid (ferric chloride) as raw materials. It was then analyzed with a Fourier transform infrared (FTIR) spectrometer. The results showed that the deep eutectic solvent was formed by hydrogen bonding between Br?nsted acid and Lews acid. Extraction desulfurization with this deep eutectic solvent as the extractant was investigated, and the optimum desulfurization conditions were obtained as follows. When the molar ratio of Br?nsted acid to Lews acid is 1 $∶$ 0.5, the desulfurization temperature is 30 °C, and the ratio of solvent to oil is 1 $∶$ 5, the proposed extractant demonstrates a favorable desulfurization effect on the simulated oil, gasoline, and diesel.

Key words: Deep eutectic solvent, Extraction, Desulfurization

摘要：

以Br?nsted酸（羧酸）和Lews酸（三氯化铁）为原料，通过搅拌方法使之形成低共熔溶剂，并采用红外光谱分析仪对低共熔溶剂进行分析。结果表明，Br?nsted酸与Lews酸通过氢键作用形成低共熔溶剂。以低共熔溶剂为萃取剂进行萃取脱硫研究，得出最佳脱硫条件：Br?nsted酸与Lews的物质的量比为1∶0.5，脱硫温度为30 ℃，剂油体积比为1∶5；在最佳脱硫条件下，低共熔溶剂对模拟油、汽油和柴油有较好的脱硫效果。

关键词: 低共熔溶剂, 萃取, 脱硫

CLC Number:

TE624

Siyu Chen, Shizhao Zhuang, Xiuping Li, Rongxiang Zhao. Extraction Desulfurization with Synthesized Lews⁃Brönsted Deep Eutectic Solvent at Room Temperature[J]. Journal of Petrochemical Universities, 2022, 35(4): 33-37.

陈思宇, 庄仕钊, 李秀萍, 赵荣祥. 室温合成Lews⁃Brönsted型低共熔溶剂萃取脱硫研究[J]. 石油化工高等学校学报, 2022, 35(4): 33-37.

Figures/Tables 8

Fig.1 Infrared spectroscopy of Br?nsted acid,Lews acid and deep eutectic solvent

Fig.2 Influence of five kinds of deep eutectic solvent on desulfurization

Fig.3 Influence of quantitative ration of C1?Br?nsted acid and Lews acid on desulfurization

Fig.4 Influence of reaction temperature on desulfurization

Fig.5 Influence of volume ratio of catalyst oil on desulfurization

Fig.6 Influence of sulfide type on desulfurization efficiency

Fig.7 Desulfurization effect of C1?Br?nsted?Lews deep eutetic solvent on gasoline and diesel

Fig.8 The number of times of extraction on the desulfurization efficiency

References 15

1	魏书梅，张晓飞，徐亚荣.FCC汽油脱硫工艺技术研究进展［J］.当代化工，2017，46（5）：917⁃920.
	Wei S M，Zhang X F，Xu Y R.Research progress of desulfurization technology of FCC gasoline［J］.Contemporay Chemical Industry，2017，46（5）：917⁃920.
2	王建龙，赵地顺，周二鹏，等.吡啶类离子液体在汽油萃取脱硫中的应用研究［J］.燃料化学学报，2007，35（3）：293⁃296．
	Wang J L，Zhao D S，Zhou E P，et al.Desulfurization of gasoline by extraction with N⁃alkyl⁃pyridinium⁃based ionic liquids［J］.Journal of Fuel Chemistry and Technology，2007，35（3）：293⁃296.
3	Gao H，Guo C，Xing J，et al.Extraction and oxidative desulfurization of diesel fuel catalyzed by a Brønsted acidic ionic liquid at room temperature［J］.Green Chemistry，2010，12（7）：1220⁃1224.
4	Lo W H，Yang H Y，Wei G T.One⁃pot desulfurization of light oils by chemical oxidation and solvent extraction with room temperature ionic liquids［J］.Green Chemistry，2003，5（5）：639⁃642.
5	Zhu W，Zhang J，Li H，et al.Fenton⁃like ionic liquids/H₂O₂ system：One⁃pot extraction combined with oxidation desulfurization of fuel［J］.RSC Advances，2012，2（2）：658⁃664.
6	Xiao J，Wu L，Wu Y，et al.Effect of gasoline composition on oxidative desulfurization using a phosphotungstic acid/activated carbon catalyst with hydrogen peroxide［J］.Applied Energy，2014，113：78⁃85.
7	张进，朴香兰，朱慎林.离子液体对燃油含硫化合物的萃取性能研究［J］.化学试剂，2006，28（7）：385⁃387.
	Zhang J，Piao X L，Zhu S L.Extraction performances of ionic liquid for sulfur compounds in oil［J］.Chemical Reagents，2006，28（7）：385⁃387.
8	Shah D，Gapeyenko D，Urakpayev A，et al.Molecular dynamics simulations on extractive desulfurization of fuels by tetrabutylammonium chloride based deep eutectic solvents［J］.Journal of Molecular Liquids，2019，274：254⁃260.
9	Hao L，Su T，Hao D，et al.Oxidative desulfurization of diesel fuel with caprolactam⁃based acidic deep eutectic solvents：Tailoring the reactivity of DESs by adjusting the composition［J］.Chinese Journal of Catalysis，2018，39（9）：1552⁃1559.
10	方静，张淑婷，李婷婷，等.离子液体用于燃油萃取脱硫的选择与过程优化［J］.化工学报，2017，68（9）：3434⁃3441.
	Fang J，Zhang S T，Li T T，et al.Selection and process optimization of ionic liquids for desulfurization［J］.CIESC Journal，2017，68（9）：3434⁃3441.
11	张盈盈，陆小华，冯新，等.胆碱类低共熔溶剂的物性及应用［J］.化学进展，2013，25（6）：881⁃892.
	Zhang Y Y，Lu X H，Feng X，et al.Propertied and application of cholone⁃based deep eutecite solvents［J］.Progress in Chemistry，2013，25（6）：881⁃892.
12	Bosmann A，Datsevich L，Jess A，et al.Deep desulfurization of diesel fuel by extraction with ionic liquids［J］.Chemical Communications，2001（23）：2494⁃2495.
13	Liu A，Zhu M，Dai B，et al.A novel high⁃performance SnO₂ catalyst for oxidative desulfurization under mild conditions［J］.Applied Catalysis A⁃General，2019，583：117134⁃117141.
14	周仕鑫，张静，乔海燕，等.氧化⁃萃取法脱除减黏裂化柴油中硫化物［J］.辽宁石油化工大学学报，2020，40（2）:6⁃10.
	Zhou S X，Zhang J，Qiao H Y，et al.Oxidation⁃extraction desulfurization of visbreaking diesel fuel［J］.Journal of Liaoning Shihua University，2020，40（2）：6⁃10.
15	马锐，宋永一，张庆军，等.船用残渣型燃料油脱硫技术进展［J］.石油化工高等学校学报，2021,34（1）：15⁃21.
	Ma R，Song Y Y，Zhang Q J，et al.Progress of residual marine fuel desulfurization technology［J］.Journal of Petrochemical Universities，2021，34（1）：15⁃21.

[1]	Bo Yu, Jianghua Ling, Fuzhi Jia, Mei Liu. Separation and Recovery of Aluminum and Nickel from Alkali Leaching Residue of Spent Catalysts [J]. Journal of Petrochemical Universities, 2023, 36(2): 20-26.
[2]	Yana Ju, Yalin Zhang, Ran Zhang, Shaotong Song, Lü Zhongwu, Xiaoliang Yuan, Yang Li, Pei Wu. Study on the Effect of Metal Dispersion on the Catalytic Activity of Nickel⁃Based Catalysts [J]. Journal of Petrochemical Universities, 2022, 35(5): 71-77.
[3]	Jinyi Li, Xianbo Luo, Yingxian Liu, Zongbin Liu, Haichao Feng, Ke Chen. Experimental Study on Influence Factors for High PV Water Flooding Efficiency in LD Heavy Oil Reservoir [J]. Journal of Petrochemical Universities, 2021, 34(6): 42-49.
[4]	Zhang Hao， Li Xiuping， Zhao Rongxiang. Preparation of V₂O₅/g⁃C₃N₄ Catalyst and Desulfurization Ability in Model Oil [J]. Journal of Petrochemical Universities, 2021, 34(1): 7-14.
[5]	Ma Rui1， Song Yongyi， Zhang Qingjun， Zhang Shudong， Liu Jihua， Li Xiaohui， Zhang Qingyao. Progress of Residual Marine Fuel Desulfurization Technology [J]. Journal of Petrochemical Universities, 2021, 34(1): 15-21.
[6]	Li Shuanglin， Wei Min， Wang Haiyan. Research Progress of S⁃Zorb Reaction Adsorption Desulfurization Technology [J]. Journal of Petrochemical Universities, 2020, 33(6): 19-25.
[7]	Shang Yutong， Yang Lina， Guan Jingguo， Li jian. Progress in Photocatalytic Oxidation Desulfurization Catalysts [J]. Journal of Petrochemical Universities, 2020, 33(2): 12-17.
[8]	The Effect of Solvent pH Value on Acid Active Site Construction and Desulfurization Performance of Ce?SBA?15 Desulfurization Adsorbent. The Effect of Solvent pH Value on Acid Active Site Construction and Desulfurization Performance of Ce⁃SBA⁃15 Desulfurization Adsorbent [J]. Journal of Petrochemical Universities, 2019, 32(5): 14-18.
[9]	Wang Xinbo, Zhao Rongxiang, Li Xiuping, Lin Kehong. Preparation of Rodlike Iron Oxide and Its Modification-Ultrasonic Desulfurization Performance [J]. Journal of Petrochemical Universities, 2018, 31(01): 30-34.
[10]	. [J]. , 2016, 29(5): 1-8.
[11]	Ma Zhiyan. Super Gravity Method of Refinery Dry Gas Selectivity MDEA Desulfurization Experiment Research [J]. Journal of Petrochemical Universities, 2016, 29(3): 18-22.
[12]	Chen Yifei Ji Dekun, Ding Fuchen,Chi Yaoling, Yi Yufeng. Effects of Binder Component to Adsorptive Desulfurization Catalyst for FCC Gasoline on Desulfurization Performance and Mechanical Strength [J]. Journal of Petrochemical Universities, 2016, 29(2): 18-22.
[13]	Ren Jing,Cao Guangwei, Zhang Yong. Adsorptive Desulfurization of Gasoline with Cu(I) Based MetalOrganic Framework [J]. Journal of Petrochemical Universities, 2015, 28(3): 41-44.
[14]	Yin Feng,Qin Yucai,Yu Wenyu,et al. Preparation and Characterization of TiO₂MCM41 and  Its Performance on the Desulfurization [J]. Journal of Petrochemical Universities, 2014, 27(6): 1-6.
[15]	Wei Jianming,Du Feng,Zhang Xingong,et al. Integrated Processing of Furfural Extraction and Catalytic  Cracking on Qingdao Petrochemical Coking Gas Oil [J]. Journal of Petrochemical Universities, 2014, 27(5): 7-11.