载体表面性质调控Pt⁃Sn/γ⁃Al2O3催化剂丙烷脱氢性能

doi:10.12422/j.issn.1006-396X.2023.01.006

摘要/Abstract

摘要：

Al₂O₃载体的性质是影响丙烷脱氢Pt?Sn/γ?Al₂O₃催化剂性能的关键因素。采用450、650、850 ℃三种焙烧温度制备了γ?Al₂O₃载体，运用XRD、XRF、NH₃?TPD、Py?FTIR、CO?FTIR、OH?FTIR等表征手段系统研究了载体和其负载型催化剂的结构和性质，使用固定床在线分析微型反应装置评价了丙烷脱氢反应性能，并对气相产物分布和结焦性质进行了分析。结果表明，随着焙烧温度的升高，γ?Al₂O₃载体的表面酸量减少，850 ℃高温焙烧几乎完全消除了表面弱L酸中心，这说明γ?Al₂O₃表面配位不饱和Al位点和表面-OH数量随焙烧温度的升高而减少，这一特征不利于金属活性中心的高度分散；CO?FTIR和TEM表征结果均证实了在Pt?Sn/γ?Al₂O₃?850催化剂上形成了更大的Pt团簇，更多的饱和配位Pt活性相结构会促进深度脱氢等副反应的发生，降低丙烯产物的选择性。

关键词: 氧化铝, 表面性质, 负载型催化剂, 丙烷脱氢, 焙烧

Abstract:

The properties of alumina supports are the key factors affecting the propane dehydrogenation performance of Pt?Sn/γ?Al₂O₃ catalysts.In this paper,γ?Al₂O₃ supports were prepared at three calcination temperatures of 450,650,850 ℃,and the structures and properties of the supports and supported catalysts were systematically studied by XRD,XRF,NH₃?TPD,Py?FTIR, CO?FTIR,OH?FTIR,and other characterization methods.The properties of the propane dehydrogenation reaction were evaluated by a fixed?bed micro?reaction evaluation device with online analysis,and the gas?phase product distribution and coking properties were analyzed.The results show that with the increase in calcination temperature,the surface acid content of γ?Al₂O₃ supports decreases,and calcination at 850 ℃ almost eliminates the weak L acid centers on the surface.This indicates that the number of coordinated unsaturated Al sites on the surface of γ?Al₂O₃ and surface hydroxyl groups decreases as the calcination temperature grows,which is not conducive to the high dispersion of metal active centers.Both CO?FTIR and TEM results confirm the formation of larger Pt clusters on Pt?Sn/γ?Al₂O₃?850,and more Pt active phase structure with saturated coordination can promote the occurrence of side reactions such as deep dehydrogenation and reduce the selectivity of propylene products.

Key words: Alumina, Surface properties, Supported catalyst, Propane Dehydrogenation, Calcination

中图分类号:

TQ032

崔明彧, 焦建豪, 康津铭, 刘世佳, 关慧敏, 宋丽娟. 载体表面性质调控Pt⁃Sn/γ⁃Al₂O₃催化剂丙烷脱氢性能[J]. 石油化工高等学校学报, 2023, 36(1): 40-47.

Mingyu Cui, Jianhao Jiao, Jinming Kang, Shijia Liu, Huimin Guan, Lijuan Song. Control of Propane Dehydrogenation Performance of Pt⁃Sn/γ⁃Al₂O₃ Catalysts by Support Surface Properties[J]. Journal of Petrochemical Universities, 2023, 36(1): 40-47.

图/表 9

图1 拟薄水铝石及γ?Al2O3系列载体、Pt?Sn/γ?Al2O3系列催化剂的XRD谱图

Fig.1 XRD patterns of pseudo?boehmite and γ?Al2O3 series supports,Pt?Sn/γ?Al2O3 series catalysts

表1 Pt?Sn/γ?Al2O3系列催化剂的XRF分析

Table 1 XRF Analysis of Pt?Sn/γ?Al2O3 series catalysts

组分	w/%
组分	Pt⁃Sn/ γ⁃Al₂O₃⁃450	Pt⁃Sn/ γ⁃Al₂O₃⁃650	Pt⁃Sn/ γ⁃Al₂O₃⁃850
Al₂O₃	94.810	95.110	94.730
Na₂O	1.100	0.990	1.400
Cl	0.946	0.861	0.750
SnO₂	0.694	0.653	0.745
Pt	0.675	0.631	0.681
SiO₂	0.523	0.490	0.460
MgO	0.430	0.438	0.446
CaO	0.424	0.399	0.368
SO₃	0.179	0.176	0.196

图2 Pt?Sn/γ?Al2O3系列催化剂的TEM及Pt和Sn的Mapping图

Fig.2 TEM and Pt?Sn Mapping of Pt?Sn/γ?Al2O3 series catalysts

图3 γ?Al2O3系列载体的OH?FTIR、Py?FTIR光谱

Fig.3 OH?FTIR and Py?FTIR spectra of γ?Al2O3 series carriers

图4 Pt?Sn/γ?Al2O3系列催化剂的NH3?TPD谱图

Fig.4 NH3?TPD spectra of Pt?Sn/γ?Al2O3 series catalysts

表2 Pt?Sn/γ?Al2O3系列催化剂的酸量

Table 2 The acid content of Pt?Sn/γ?Al2O3 series catalysts

样品	酸量/(mmol·g^-1)
样品	WA	MA	SA
Pt⁃Sn/γ⁃Al₂O₃⁃450	2.726 5	4.011 8	7.487 7
Pt⁃Sn/γ⁃Al₂O₃⁃650	2.444 3	3.965 6	7.058 5
Pt⁃Sn/γ⁃Al₂O₃⁃850	1.933 3	3.148 5	5.969 0

图5 Pt?Sn/γ?Al2O3系列催化剂的CO?FTIR谱图

Fig.5 CO?FTIR spectra of Pt?Sn/γ?Al2O3 series catalysts

图6 反应后Pt?Sn/γ?Al2O3系列催化剂的TG、DTG曲线

Fig.6 TG and DTG curves of the reacted Pt?Sn/γ?Al2O3 series catalysts

图7 Pt?Sn/γ?Al2O3系列催化剂的丙烷脱氢反应性能

Fig.7 Propane dehydrogenation reaction performance of Pt?Sn/γ?Al2O3 series catalysts

参考文献 18

1	Sattler J，Gonzalez⁃Jimenez I D，Mens A M，et al.Operando UV⁃Vis spectroscopy of a catalytic solid in a pilot⁃scale reactor： Deactivation of a CrOx/Al₂O₃ propane dehydrogenation catalyst［J］.Chemical Communications，2013，49（15）：1518⁃1520.
2	刁国华，潘立卫，范琳，等.二氧化碳电化学还原用铜基催化剂研究进展［J］.辽宁石油化工大学学报，2021，41（4）：1⁃8.
	Diao G H，Pan L W，Fan L，et al.Review of copper⁃based catalysts for electrocatalytic reduction of carbon dioxide［J］.Journal of Liaoning Petrochemical University，2021，41（4）：1⁃8.
3	Searles K，Chan K W，Burak J，et al.Highly productive propane dehydrogenation catalyst using silica⁃supported Ga⁃Pt nanoparticles generated from single⁃sites［J］.Journal of the American Chemical Society，2018，140（37）：11674⁃11679.
4	Sokolov S，Stoyanova M，Rodemerck U，et al.Comparative study of propane dehydrogenation over V⁃，Cr⁃，and Pt⁃based ⁃catalysts：Time on⁃stream behavior and origins of deactivation［J］.Journal of Catalysis，2012，293（9）：67⁃75.
5	Xiong H，Lin S，Goetze J，et al.Thermally stable and regenerable platinum⁃tin clusters for propane dehydrogenation prepared via atom trapping on ceria［J］.Angewandte Chemie，2017，56（31）：8986⁃8991.
6	Sattler J，Ruiz⁃Martinez J，Santillan⁃Jimenez E，et al.Catalytic dehydrogenation of light alkanes on metals and metal oxides［J］.Chemical Reviews，2014，114（20）：10613⁃10653.
7	Sun P P，Siddiqi G，William C，et al.Novel Pt/Mg（In）（Al）O catalysts for ethane and propane dehydrogenation［J］.Journal of Catalysis，2011，282（1）：165⁃174.
8	Razavian M，Fatemi S.Synthesis and application of ZSM⁃5/SAPO⁃34 and SAPO⁃34/ZSM⁃5 composite systems for propylene yield enhancement in propane dehydrogenation process［J］.Microporous & Mesoporous Materials，2015，201：176⁃189.
9	Komasi M，Fatemi S，Razavian M.Hierarchical SAPO⁃34 catalytic support for superior selectivity toward propylene in propane dehydrogenation process［J］.Korean Journal of Chemical Engineering，2015，32（7）：1289⁃1296.
10	Ren Y，Jie W，Hua W，et al.Ga₂O₃/HZSM⁃48 for dehydrogenation of propane：Effect of acidity and pore geometry of support［J］.Journal of Industrial & Engineering Chemistry，2012，18（2）：731⁃736.
11	Shi L，Deng G M，Li W C，et al.Al₂O₃ Nanosheets rich in pentacoordinate Al³⁺ ions stabilize Pt‐Sn clusters for propane dehydrogenation［J］.Angewandte Chemie International Edition，2016，54（47）：13994⁃13998.
12	Li W，Wang Q，Xu J，et al.Probing the surface of γ⁃Al₂O₃ by oxygen⁃17 dynamic nuclear polarization enhanced solid⁃state NMR spectroscopy［J］.Physical Chemistry Chemical Physics Pccp，2018，20（25）：17218⁃17225.
13	Amirsalari A，Shayesteh S F.Effects of pH and calcination temperature on structural and optical properties of alumina nanoparticles［J］.Superlattices & Microstructures，2015，82（6）：507⁃524.
14	Gao X Q，Lu W D，Hu S Z，et al.Rod⁃shaped porous alumina⁃supported Cr₂O₃ catalyst with low acidity for propane dehydrogenation［J］.Chinese Journal of Catalysis，2019，40（2）：184⁃191.
15	Vu B K，Song M B，Ahn I Y，et al.Pt–Sn alloy phases and coke mobility over Pt–Sn/Al₂O₃ and Pt–Sn/ZnAl₂O₄ catalysts for propane dehydrogenation［J］.Applied Catalysis A General，2011，400（1⁃2）：25⁃33.
16	赵琰.氧化铝、改性氧化铝及硅酸铝的酸性特征［J］.工业催化，2002，10（2）：54⁃56.
	Zhao Y.Acidity characteristics of alumina，modified alumina and aluminosilicate［J］.Industrial Catalysis，2002，10（2）：54⁃56.
17	赵琰.氧化铝，改性氧化铝及硅酸铝的酸性特征（续）［J］.工业催化，2002，10（3）：57⁃58.
	Zhao Y.Acidic characteristics of alumina，modified alumina and aluminosilicate（Continued）［J］.Industrial Catalysis，2002，10（3）：57⁃58.
18	Wang H Z，Sun L L，Sui Z J，et al.Coke formation on Pt⁃Sn/Al₂O₃ catalyst for propane dehydrogenation［J］.Industrial & Engineering Chemistry Research，2018，57（26）：8647⁃8654.

[1]	康津铭, 焦建豪, 秦玉才, 杨野, 王焕, 宋丽娟. Pt0.5⁃Snx/γ⁃Al₂O₃催化剂对丙烷脱氢反应性能的影响[J]. 石油化工高等学校学报, 2023, 36(4): 34-39.
[2]	党迎喜,沈健,程丽华,邓益强,王寒露,王雷. 催化裂化汽油加氢脱硫负载型催化剂的研究进展[J]. 石油化工高等学校学报, 2016, 29(5): 1-8.
[3]	甄晓波,王鼎聪,丁巍,赵德智,曹祖宾. 纳米自组装催化剂对催化裂化混合油抗结焦性能的研究[J]. 石油化工高等学校学报, 2013, 26(1): 11-16.
[4]	刘岩,商丽艳,李艳,翟玉春. 纳米氧化铝载体的制备及孔性质研究[J]. 石油化工高等学校学报, 2010, 23(2): 13-15.
[5]	钱建华, 秦金兰, 刘琳, 邢锦娟, 田静博. 负载型纳米催化剂催化合成丁酸苄酯的性能[J]. 石油化工高等学校学报, 2008, 21(3): 43-45.

载体表面性质调控Pt⁃Sn/γ⁃Al₂O₃催化剂丙烷脱氢性能

Control of Propane Dehydrogenation Performance of Pt⁃Sn/γ⁃Al₂O₃ Catalysts by Support Surface Properties

HTML

PDF

可视化

摘要/Abstract

引用本文

使用本文

图/表 9

参考文献 18

相关文章 5

编辑推荐

Metrics