辽宁石油化工大学学报

辽宁石油化工大学学报 ›› 2017, Vol. 37 ›› Issue (4): 11-14.DOI: 10.3969/j.issn.1672-6952.2017.04.003

• 石油化工 • 上一篇    下一篇

水基钻井液用阳离子型封堵剂的合成及性能

林子杨， 黄 金， 马 诚   

  1. 辽宁石油化工大学 化学化工与环境学部，辽宁 抚顺 113001
  • 收稿日期:2017-03-13 修回日期:2017-04-25 出版日期:2017-08-25 发布日期:2017-08-29
  • 通讯作者: :马诚(1982-),男,博士,副教授,从事油田化学及油气井工作液方面的研究;E-mail:kkmc2002@163.com。
  • 作者简介::林子杨(1996-),男,本科生,应用化学专业,从事聚合物合成和钻井液处理方面的研究;E-mail:903976149@qq.com。
  • 基金资助:
    :辽宁省大学生创新创业训练计划项目(201610148009);辽宁省教育厅科学技术研究项目一般项目(L2016019);辽 宁石油化工大学科学基金项目(2015XJJ-001)。

Synthesis and Performance of Cationic Plugging Agent  Used in Water-Based Drilling Fluid

Lin Ziyang, Huang Jin, Ma Cheng   

  1. Chemical of Chemistry, Chemical Engineering and Environmental Engineering,  Liaoning Shihua University, Fushun Liaoning 113001, China
  • Received:2017-03-13 Revised:2017-04-25 Published:2017-08-25 Online:2017-08-29

PDF

摘要： 以苯乙烯（St）、丙烯酸丁酯（BA）及阳离子可聚合单体，利用乳液聚合方法制备水基钻井液用阳离子型封堵剂，采用红外光谱分析了封堵剂的结构特点。泥球浸泡实验结果表明，质量分数为5.0%的阳离子型封堵剂乳液和饱和盐水抑制黏土水化性能相当。评价了阳离子型封堵剂对CaC12无土相钻井液性能的影响。结果表明，加入质量分数为2.0%的阳离子型封堵剂，可将CaC12质量分数为25.0%的无土相钻井液的高温高压滤失量（120～130 ℃）控制在10.0 mL左右。

关键词: 致密油气, 井壁稳定, 钻井液, 阳离子型封堵剂

Abstract: The cationic plugging agent of water base drilling fluid was prepared by emulsion polymerization with styrene (St), butyl acrylate (BA) and cationic polymerizable monomer. The structure characteristics of the plugging agent were analyzed by infrared spectrum. The result of soaking test with clay ball showed that cationic plugging agent emulsion with a mass fraction of 5.0% was equivalent in inhibiting clay hydration property of saturated brine. The effect of cationic plugging agent on the properties of CaCl2 free phase drilling fluid was evaluated. The results showed that the high temperature and high pressure filtration (120~130 ℃) could be controlled at about 10 mL for the non phase drilling fluid with CaCl2 content of 25.0% when the cationic plugging agent is 2.0%.

Key words: Tight oil and gas, Borehole stability, Drilling fluid, Cationic plugging agent

引用本文

林子杨， 黄 金， 马 诚. 水基钻井液用阳离子型封堵剂的合成及性能[J]. 辽宁石油化工大学学报, 2017, 37(4): 11-14.

Lin Ziyang, Huang Jin, Ma Cheng. Synthesis and Performance of Cationic Plugging Agent  Used in Water-Based Drilling Fluid[J]. Journal of Liaoning Petrochemical University, 2017, 37(4): 11-14.

使用本文

0
    /   /   推荐

导出引用管理器 EndNote|Ris|BibTeX

链接本文: http://journal.lnpu.edu.cn/CN/10.3969/j.issn.1672-6952.2017.04.003

               http://journal.lnpu.edu.cn/CN/Y2017/V37/I4/11



网站版权 © 2021《辽宁石油化工大学学报》编辑部

本系统由北京玛格泰克科技发展有限公司设计开发